面向LNG运输船数字孪生船岸数据回传关键技术研究

doi:10.19423/j.cnki.31-1561/u.2026.022

船舶 ›› 2026, Vol. 37 ›› Issue (04): 32-40.DOI: 10.19423/j.cnki.31-1561/u.2026.022

面向LNG运输船数字孪生船岸数据回传关键技术研究

陈磊¹, 王磊^1,*, 任忠杰¹, 宫克²

1.沪东中华造船（集团）有限公司上海 201913;
2.上海中远海运液化天然气投资有限公司上海 200080

收稿日期:2026-01-30 修回日期:2026-04-14 发布日期:2026-08-28
通讯作者: 王磊（1984—）,男,硕士,研究员级高级工程师。研究方向：智能船舶、LNG运输船轮机设计等;任忠杰（1981—）,男,硕士,高级工程师。研究方向：智能船舶、LNG运输船电气设计等;宫克（1996—）,男,本科,助理工程师。研究方向：船舶电子电气工程。
作者简介:陈磊（1997—）,女,硕士,工程师。研究方向：智能船舶、LNG运输船电气设计等。
基金资助:
LNG运输船舶数字孪生技术应用研究（2025-CSET-007）

Research on Key Technologies for Ship-to-Shore Data Transmission of LNG Carrier Digital Twins

CHEN Lei¹, WANG Lei^1,*, REN Zhongjie¹, GONG Ke²

1. Hudong-Zhonghua Shipbuilding （Group） Co., Ltd., Shanghai 201913, China;
2. COSCO SHIPPING LNG Investment （Shanghai） Co., Ltd., Shanghai 200080, China

Received:2026-01-30 Revised:2026-04-14 Published:2026-08-28

摘要/Abstract

摘要： 针对高保真液化天然气（liquefied natural gas,LNG）运输船数字孪生体构建中所面临的数据体量大、传输带宽受限等技术瓶颈,文章提出一套集成可靠传输与高效压缩的船岸数据回传系统。首先,该系统使用标准化接口实现多源数据采集,通过数据分级回传策略提炼其价值,并引入GZip算法对液货舱系统等关键数据进行高效压缩。其次,该系统基于消息队列遥测传输协议的数据回传架构,通过引入服务质量等级确认机制,提出智能断网续传策略以实现船端本地缓存、确保数据完整传输。最终,经实船应用验证,该系统在确保数据100%完整回传的前提下,实现了超过93%的压缩率,并在受限带宽下显著降低了端到端回传时延。该研究从传输效率、可靠性与实时性这3个维度全面提升了LNG运输船数字孪生体数据回传的有效性,验证了所提传输策略与模块的合理性,为高价值船舶数字孪生系统的工程化应用奠定了基础。

关键词: 液化天然气运输船, 数字孪生, 船岸数据回传, GZip算法, MQTT协议

Abstract: To address the technical bottlenecks such as large data volume and limited transmission bandwidth encountered in constructing a high-fidelity digital twin of a liquefied natural gas (LNG) carrier, this paper proposes a ship-to-shore data transmission system that integrates reliable transmission and efficient compression. First, the system uses standardized interfaces to achieve multi-source data acquisition, and through a data hierarchical transmission strategy, extracts the value of the data. On this basis, the GZip algorithm is introduced to efficiently compress key data such as those from the liquid cargo tank system. Second, based on the data transmission architecture of the Message Queuing Telemetry Transport (MQTT) protocol, a quality of service (QoS) level confirmation mechanism is introduced to ensure effective data transmission, and an intelligent network disconnection recovery strategy is proposed to enable local caching at the ship end and ensure complete data transmission. Finally, real ship application verification shows that the proposed system achieves a compression rate of over 93% while ensuring 100% complete data transmission, and significantly reduces the end-to-end transmission delay under limited bandwidth. This study comprehensively improves the effectiveness of data transmission for the digital twin of LNG carriers from three dimensions—transmission efficiency, reliability, and real-time performance—and verifies the effectiveness of the proposed transmission strategy and modules, laying the foundation for the engineering application of high-value ship digital twin systems.

Key words: liquefied natural gas (LNG) carrier, digital twin, ship-to-shore data transmission, GZip compression algorithm, message queuing telemetry transport (MQTT) protocol

中图分类号:

陈磊, 王磊, 任忠杰, 宫克. 面向LNG运输船数字孪生船岸数据回传关键技术研究[J]. 船舶, 2026, 37(04): 32-40.

CHEN Lei, WANG Lei, REN Zhongjie, GONG Ke. Research on Key Technologies for Ship-to-Shore Data Transmission of LNG Carrier Digital Twins[J]. Ship & Boat, 2026, 37(04): 32-40.

参考文献

[1] 钟林,王阳,敬佳佳,等. 我国LNG产业储运装备发展现状与展望[J]. 中国重型装备,2022(4): 11-17.
[2] Xia G H,Zhou Z Y,Han F L,et al.Real-time digital twin of autonomous ships based on virtual-physical mapping model[J]. Physics of Fluids,2024,36(8): 087109.
[3] 张安通,郭煜,鲍嘉伟,等. 船舶智能系统虚实融合仿真测试技术研究[J]. 中国造船,2025,66(1): 146-156.
[4] 涂小龙. 基于能效数据驱动的长江混合动力船舶能量管理策略研究[D]. 武汉: 武汉理工大学,2023.
[5] 董浩,宋亮,化存卿,等. 海上通信技术发展与研究综述[J]. 电信科学,2022,38(5):1-17.
[6] Liu W Q,Mei F Q,Wang C H,et al.Data compression device based on modified LZ4 algorithm[J]. IEEE Transactions on Consumer Electronics,2018,64(1): 110-117.
[7] 吴晓阳. 提升算法下船舶AIS航迹数据压缩方法[J]. 舰船科学技术,2023,45(16): 157-160.
[8] 黄林青. 远程频谱监测数据实时高效压缩与回传关键技术[D]. 成都: 电子科技大学,2025.
[9] Jurdana I,Lopac N,Wakabayashi N,et al.Shipboard data compression method for sustainable real-time maritime communication in remote voyage monitoring of autonomous ships[J]. Sustainability,2021, 13(15): 8264.
[10] Alatram A,Sikos L F,Johnstone M,et al.DoS/DDoS-MQTT-IoT: a dataset for evaluating intrusions in IoT networks using the MQTT protocol[J]. Computer Networks,2023,231(2): 3-13.
[11] Pan C S,Zhang C X,Shi J F,et al.Adaptive Dzip transformer-based data compression technology for digital twin systems[J]. IEEE Internet of Things Journal,2025,12(22):6537-6549.
[12] 邹英杰. 基于MQTT协议和Gzip压缩算法的长期监测终端的研制[D].桂林:桂林理工大学,2023.
[13] 侯艳杰,焦少侠,陈天祥,等. MQTT协议在机舱监测报警系统中的应用[J]. 船舶标准化工程师,2024,57(增刊1): 45-49.
[14] 袁竞. 基于Huffman编码的LZSS与LZW联合压缩算法研究[J]. 电脑知识与技术,2025,21(15): 60-62.

编辑推荐

Metrics

联系电话：（021）63161688-105006
传真：（021）63151255
E-mail：chuanbo@maric.com.cn

面向LNG运输船数字孪生船岸数据回传关键技术研究

Research on Key Technologies for Ship-to-Shore Data Transmission of LNG Carrier Digital Twins

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

[1]	李凯;钱浩;龚梦瑶;王晓磊;. 基于数字孪生技术的数字化舰船及其应用探索[J]. 船舶, 2018, 29(06): 101-108.
[2]	李银涛;任飞华;. 小型多功能液化天然气运输船集管设计[J]. 船舶, 2016, 27(03): 73-85.
[3]	李银涛;. 双燃料发动机电力推进LNG船可燃气体探测系统设计简介[J]. 船舶, 2011, 22(02): 42-48.